TCS Court Resurfacer With Sand
Surface Preparation: Surface must be cleaned entirely of dust, dirt and debris. Repair of surface defects, depressions and cracks should be completed prior to application. All repairs must be flush and smooth to adjoining surfaces for optimum results. New asphalt must cure 30 days and new concrete must cure 28 days prior to application. Concrete surfaces should have a medium-broom finish or similar roughened texture. TCS Concrete Primer shall be applied on properly prepared concrete prior to application of TCS Court Resurfacer with sand.
On concrete surfaces, ensure:
• No curing compounds are used (except for water-based acrylic curing compounds)
• A vapor barrier and good perimeter drainage is installed to prevent moisture accumulation beneath the court surface.
• Surface is acid etched with muriatic or phosphoric acid, after the 28 day cure period, and rinsed well prior to application of TCS Coating System.
Mixing Procedures: Mix materials to a smooth uniform consistency with a hand-held or drill mixing paddle. The following mix designs are based on 10 gallons of TCS Court Resurfacer with sand for ease of calculation:
TCS Court Resurfacer.............5 gallons
Water.......................................2 gallons
Application: Apply with a soft rubber squeegee. Scrape rough areas and ridges when dry and prior to the next coat. Allow 1 to 4 hours to dry. Temperatures must be a minimum of 50ºF and rising both during application and for a period of at least 24 hours after applications. Do not apply when rain is forecast within 24 hours. Keep from freezing. Close container when not in use.
Coverage: Yield calculations are based on undiluted gallons of TCS Court Resurfacer with sand and vary according to surface texture and porosity within the limits below: .11 to .13 per square yard per coat.
Drying Time: TCS Court Resurfacer with sand dries in 1-4 hours under optimum drying conditions. Low ambient or low surface temperature and high humidity increase drying time.
Clean Up: Wash tools in water before material dries.
VOC: This material contains less than 150 grams of volatile organic compounds per liter.
Caution: KEEP FROM FREEZING. KEEP OUT OF REACH OF CHILDREN. Do not take internally. If swallowed, call a physician immediately. In case of contact with eyes, flush immediately with water for 15 minutes and call a physician. Do not apply when rain is imminent. When not in use, keep container tightly closed and upright to prevent leakage. Do not store in direct sunlight or above 100 ºF. In case of spillage, absorb and dispose of in accordance with Federal, State and Local regulations.
Warranty: The statements made on this label are believed to be true and accurate and are intended to provide a guide for approved application practices. As workmanship, weather, construction, equipment utilized and other variables affecting results are all beyond our control. Tennis Court Supply warrants only that the material conforms to product specifications and any liability to the buyer or use of this product is limited to the replacement value of the product only. In no event shall tennis court supply be liable for any injury, loss or damage, either direct or incidental, special or consequential, however arising in connection with material or
equipment furnished or work performed. Tennis Court Supply shall not, in any manner, be liable for any defects, variations or change in condition in the substructure over which its products are installed.
